Features of the existing units:

• Packages are available immediately, and ready for transport. (Central Alberta)
• 3Pc skid
• Frame, cylinders and motors have been removed and stored under strict manufactures guidelines
• Deferred Ariel Warranty available upon request
• Full engineering studies and document packages available(Torsional and Acoustical) 
• The existing units are fully flanged including a high amount of control and sensing transmitters.
• CRN’s for AB and BC are existing
• Sour Spec NDE PWHT and 1.8 C.A. on all pressure vessels and cooler sections
• Sweet gas purge packing system including seal pot and vacuum pump.
• Piping designed with 1/16” C.A.
• Suction, side stream, bypass and blowdown valves.
• Allen Bradly Control Logix panel
• Glycol heating system
• Motor Ventilation system

Note on Sour Service: Some/all of the existing piping system may meet 1/8” piping minimum thicknesses and can be assessed on a case by case basis based on design conditions. A reclassification and or retrofit of some of the piping system is possible to comply with full sour.

Package NDE meets or exceeds code and is aligned with industry standard code for sour service.

Engine

Brand Cummins

Model QSK50-G4 NR2

Serial Number 25434250

Manufacture Date 2018

Fuel Type Diesel

Governor Electronic

Engine Arrangement 3651170

Air Cleaner Dry Type

Starter 24 Volt Electric Starter

Alternator 24 Volt Alternator

Cooling Radiator Cooled

RPM 1800

Horsepower 2220

Generator Set Type: Stand-By

Engine Model: 3516B

Fuel Type: Diesel

Voltage: 277/480

Model: 3516B

Panel: with Autostart and Safety Shutdowns

Batteries: Yes

Hours: 641 Since New

Frequency: 60 Cycles/Hz

Phase: Three Phase

New Surplus Solar Centaur 50-6201S Genset package sitting in storage ready for deployment. This is a SoloNox package and it includes an option for extended Solar warranty.

Full application and engineering support, installation and commisioning support services favailable for your project.

Unit is located in the USA

Operating conditions 

15 psi suction 

1165 discharge 

900 RPM

Calc. Flow 6.3 MMSCF/d 

Engine and compressor comes with

Hot starts 

20" 150 Catalytic Converter DCL International Inc.

stainless exhaust 

Maxim muffler

Waukesha 7044 GSI S-4 Engine, 1,200KW – Leroy Somer 480V – 3 Phase Generator, Full Package, New Surplus, comes complete turnkey ready to go with cold weather oilfield building, skid, electric breaker, controls, low noise remote radiator with VFD, Building Electrical, parallel capable, rich burn with catalytic converter, Turn Key, ready to go. Comes with Waukesha OEM 1 Year Warranty. Manuals and Full Engineered Drawing Package Available. Dimensions approx. 16’ wide, 40’ long and 12’ high, approx. 95,000 lbs.

Delivery: Load tested and ready to go.

4 units built

Twin disc rear power take off, Model SP321P00, Battery Charger, Racon Fuel Filters, Electric Prelube pump 24V, Jacket water heater (duel), Batteries 24v, Fuel tank size is approximate.

- Manufacturer: Wartsila

- Series 220, 1200RPM, 2925 KW Mec

- Serial numbers: 281004 through 281008

- Year built: 1999 (281008 was built in 2000)

- Hours of operation:

 --281004 = 1719 hrs 

 --281005 = 1602 hrs  

 --281006 = 1762 hrs  

 --281007 = 1537 hrs  

 --281008 = 1702 hrs

• Eight x New x Caterpillar 3516B HD Generators.
• Manufactured in Germany.
• Year manufactured 2020.
• Fuel Diesel.
• Frequency 50hz.
• Voltage 400v.
• Open Type.

Generator Set Type: Stand-By

Engine Model: G3516

Fuel Type: Natural Gas

Voltage: 2400/4160

Model: G3516

Panel: with Autostart and Safety Shutdowns

Frequency: 60 Cycles/Hz

Phase: Three Phase

11.1 compression ratio

Both turbine units are in excellent condition with very low hours for their age. Each unit has had the generator end refurbished (documentation included). General refurbishment activities on the remaining items has been completed.

Units have 15,166 & 20,222 hours of use. 292 & 472 starts.

5.2MW at sea level, 59°F, no inlet or exhaust losses, 11,882 BTU/kwh on Natural Gas. Inlet and exhaust ducting, Self Cleaning inlet air filter, Electric motor starting, Outdoor enclosures, control cab with switchgear, MCC, etc.

Commissioned in 11/6/01, and maintained by Solar. Taken out of service, stored inside building 2006-2009 disassembled and moved in 2009 to present site and inspected by Solar. Generator Ends rebuilt. May 30, 2019 Borescope reports available.

2954 Hours, 

Unit was started and run (no load) August 14, 2020. Locate in Fort St, John (Canada)

New Cooling unit Design for Waukesha L5774LT- JGK4 - 2 stage, 655(IC1)/1287(IC2) psig mawp

Coolers available on the ground near Calgary, available for a new compresion apllication or for a retrofit.

These coolers could save a new packaging project substanital costs.